How to assemble IKEA FJÄLLBO TV Unit

Step-by-step assembly

1. 

   Step 1 · manual step 1–2

   Slide the rail onto the end frame and fix it with 1 screw (107616).

   The frame is built lying down on the rug.

   ▶ Watch this step (0:17)

2. 

   Step 2 · manual step 3–4

   Slide on the long mesh panel and fix it with 1 screw (107616).

   This panel becomes the bottom shelf.

   ▶ Watch this step (0:24)

3. 

   Step 3 · manual step 5–6

   Fit the second rail and fix it with 1 screw (107616).

   ▶ Watch this step (0:32)

4. 

   Step 4 · manual step 7–8

   Fit the second end frame and fix it with 3 screws (107616).

   Do this with two people.

   ▶ Watch this step (0:39)

5. 

   Step 5 · manual step 9

   Screw the 2 arched brackets to the front legs — 2 screws (107616) each.

   ▶ Watch this step (0:47)

6. 

   Step 6 · manual step 10

   Fix each bracket to the bottom shelf with 2 sleeves and 2 bolts.

   Sleeves 152526 go in from one side, bolts 152527 from the other.

   ▶ Watch this step (0:54)

7. 

   Step 7 · manual step 11

   Screw 4 feet (122158) into the ends of the end-frame legs.

   ▶ Watch this step (1:02)

8. 

   Step 8 · manual step 12–13

   Screw on the 3 front posts with 6 screws (139212).

   The 2 posts with hinge holes go at the sides, the plain one in the middle.

   ▶ Watch this step (1:08)

9. 

   Step 9 · manual step 14–15

   Turn it over and screw on the 3 back posts (6 × 139212).

   Again the plain post goes in the middle.

   ▶ Watch this step (1:17)

10. 

    Step 10 · manual step 16

    Screw 6 feet (122158) into the ends of the posts.

    ▶ Watch this step (1:27)

11. 

    Step 11 · manual step 17

    Stand the frame upright and lower the shelf onto the rails.

    Check which way the shelf faces — see the manual, step 17.

    ▶ Watch this step (1:33)

12. 

    Step 12 · manual step 18

    Make a starter hole with the awl, then fix the shelf with 10 screws (152497).

    5 along the front, 5 along the back.

    ▶ Watch this step (1:42)

13. 

    Step 13 · manual step 19

    Lay the top face-down on the rug and place the top frame on it.

    Check the frame’s tabs face as in the manual, step 19.

    ▶ Watch this step (1:50)

14. 

    Step 14 · manual step 20

    Pre-punch with the awl, then screw the frame to the top — 10 screws (152497).

    6 through the tabs, 4 through the cross bars.

    ▶ Watch this step (1:56)

15. 

    Step 15 · manual step 21

    Turn the top over and lower it onto the posts.

    The stubs under the frame go into the tube ends.

    ▶ Watch this step (2:04)

16. 

    Step 16 · manual step 22

    Screw the top frame to the legs and front posts — 7 screws (107616).

    ▶ Watch this step (2:11)

17. 

    Step 17 · manual step 23

    At the back, fix the 3 clips to the back posts with 3 screws (107616).

    Check the clips are turned the right way — see the manual, step 23.

    ▶ Watch this step (2:19)

18. 

    Step 18 · manual step 24

    Level the unit by turning the 10 feet.

    Use the spirit level on the top.

    ▶ Watch this step (2:26)

19. 

    Step 19 · manual step 25

    Screw 2 hinges (153334) onto each door — 16 screws (107616).

    Lay the 4 doors face-up on the rug.

    ▶ Watch this step (2:33)

20. 

    Step 20 · manual step 26

    Hang the doors: screw each hinge to the frame — 16 screws (107616).

    The outer doors hinge on the end frames, the middle two on the side posts.

    ▶ Watch this step (2:41)

21. 

    Step 21 · manual step 27

    Fit a washer (139578) with a screw (114755) on the inside of each door.

    Near the top corner on the opening side — see the manual, step 27.

    ▶ Watch this step (2:51)

22. 

    Step 22 · manual step 28

    Doors not lining up? Push the unit square, then tighten the 4 bolts.

    The bracket bolts 152527 and sleeves 152526 at the bottom front corners.

    ▶ Watch this step (2:58)

23. 

    Step 23 · manual step 29

    Fix the unit to the wall with 2 screws through the top frame.

    Wall screws and plugs are not included — use ones that suit your wall.

    ▶ Watch this step (3:05)